The Eurotunnel Class 9 or Class 9000 are six-axle high-power Bo′Bo′Bo′ single-ended electric locomotives built by the Euroshuttle Locomotive Consortium (ESCL) of Brush Traction and ABB. The class was designed for and is used exclusively to haul the LeShuttle road vehicle services through the Channel Tunnel.

Background and design Tendering for the locomotive procurement began in 1989. The specification included; a top speed of ; a terminal-to-terminal travel time of 33 minutes pulling a train; an axle load limit of ; an operating temperature range between and ; a loading gauge within the UIC 505-1 standard; a minimum curve radius of ; be able to start a shuttle train on a 1 in 160 (0.625 %) gradient with one locomotive bogie inoperative (at ), and a single locomotive should be able to start the train on the same gradient if the other locomotive failed. The operating concession agreement between the tunnel operator and the British and French governments required that there be a locomotive on either end of the train, allowing the reversing or splitting of the train in an emergency.

The design specifications implied a minimum power of , and also meant that a four-axle design would not be guaranteed to be able to supply sufficient tractive effort. ESCL proposed a six-axle Bo′Bo′Bo′ locomotive derived from the narrow-gauge EF class locomotives supplied by Brush Traction to the New Zealand Railways Corporation and won the contract with an initial order of 40 in July 1989.

The main traction electrical system consists of: two pantographs (duplicated for redundancy) collecting a 25 kV AC supply which feeds the main transformer, with separate output windings rectified to a DC link (one per bogie) using four quadrant converters. The direct current drives a three-phase inverter, which powers two asynchronous three-phase induction motors. There are two additional output windings on the transformer for the locomotive's auxiliaries and to supply power to the train vehicles.

The bogies were a fabricated steel design, with coil spring primary suspension. The traction motors and gearboxes (one per axle) were mounted to the bogie frame and connected to the wheels by a flexibly coupled quill drive. Traction links were connected to the bogie frame at a height of above rail. The locomotive superstructure is supported on coil springs on a central swing bolster, and the centre bogie allows of lateral movement to negotiate small-radius curves. Yaw dampers are also fitted.

The locomotive superstructure is a stressed-skin monocoque design. Both the bogies and superstructures were fabricated by Qualter, Hall and Company of Barnsley.

The driver's cab and exterior design of the locomotives was undertaken by DCA Design. Side windows in the locomotive cab are omitted to prevent 'segment flicker' caused by fast running in the tunnel, a potential distraction and cause of operator drowsiness. The operator's cabin is air conditioned and pressurised for comfort. The locomotive uses in-cab TVM 430 signalling. The driving cab also incorporates train manager's facilities, including safety systems such as CCTV, alarms and communication links. There is a second driving position for shunting at the rear of the locomotive.

Testing and operations The initial order for 40 units was reduced to 38, numbered 9001 to 9038. The first locomotive was completed in 1992, and two units (9003 and 9004) were tested at the Velim test track in the Czech Republic. Locomotive 9004 started its required 50,000-kilometre endurance test at Velim on 17 August 1993 and finished it on 23 September 1993.

The locomotives are maintained at the Eurotunnel depot located just beside Eurotunnel Calais Terminal at Coquelles near Calais, France. Coquelles Eurotunnel depot

The formal opening took place on 6 May 1994 with Queen Elizabeth II and François Mitterrand travelling on a shuttle through the tunnel.

The 1996 Channel Tunnel fire damaged locomotive 9030 beyond repair. It was scrapped in 1997 at the Coquelles depot.

Later subclasses 9100 subseries In 1997, Eurotunnel ordered five more locomotives and in 1998 the order was increased to a total of 14. This second batch of locomotives also had small improvements compared to the originals, including IGBT-based traction inverters instead of GTO-based and one inverter per motor instead of one per bogie.

This second batch of locomotives is numbered in the 9100 series (9101 to 9113) except for one locomotive, 9040 which was purchased as a replacement for 9030, the locomotive destroyed in the 1996 fire.

9700 subseries In 1999, Eurotunnel ordered seven locomotives with an increased power of . This third batch of locomotives was delivered between 2001 and 2003, and is numbered in the 9700 series (9701 to 9707). The higher power output allowed an increase in the length and weight of cargo shuttle trains.

9800 subseries

Since 2000, Eurotunnel has been slowly rebuilding the older 9000 and 9100 series locomotives from , replacing the main transformer, traction converters and motors. These rebuilt locomotives are numbered in the 9800 series.

By late 2017 of the 57 locomotives, 45 of them had been upgraded to the standard, while the remaining 12 had the original power.

Number rangeBuiltPowerNotes9001–90381992–19949030 withdrawn due to fire damage90401998Built to replace fire-damaged locomotive 90309101–91131998–2001Dedicated to freight shuttles9701–97072001–20029801–Rebuilt 2004–2012Rebuilt from machines

Names

After introduction the locomotives were named after opera singers. In 1997 four units were named Jungfraujoch, Lötschberg, Gotthard and Furkatunnel, after Swiss rail tunnels.

Named locomotivesNumberName9005Jessye Norman9007Dame Joan Sutherland9011José van Dam9013Maria Callas9015Lötschberg 19139018Wilhelmenia Fernandez9022Dame Janet Baker9024Gotthard 18829026Furkatunnel 19829029Thomas Allen9033Montserrat Caballé9036Alain Fondary9037Gabriel Bacquier9801Lesley Garrett9802Stuart Burrows9803Benjamin Luxon9804Victoria de los Ángeles9806Régine Crespin9808Elisabeth Söderström9809Françoise Pollet9810Jean-Philippe Courtis9812Luciano Pavarotti9814Lucia Popp9816Willard White9819Maria Ewing9820Nicolai Ghiaurov9821Teresa Berganza9823Dame Elisabeth Schwarzkopf9825Jungfraujoch 19129827Barbara Hendricks9828Kiri Te Kanawa9831Plácido Domingo9832Renata Tebaldi9834Mirella Freni9835Nicolai Gedda9838Hildegard Behrens

Notes

References

Sources

Literature

Further reading