Alliance Air Flight 7412 was a scheduled Indian domestic passenger flight from Calcutta to Delhi, operated by Indian regional airline Alliance Air. On 17 July 2000, while on approach to its first stopover in Patna, the Boeing 737-200 operating the route nose-dived and crashed into a residential area in Patna, killing 60 people including 5 on the ground.
The final report, investigated by the Indian Directorate General of Civil Aviation, concluded that the cause of the crash was due to pilot error. The aircraft was on approach with its engines at idle thrust and the crew made several maneuvers with high-pitch attitude. When the aircraft sounded a warning on an impending stall, the crew elected to execute a go-around procedure instead of a stall recovery procedure, causing the aircraft to enter an actual stall condition.
Aircraft The aircraft involved was a Boeing 737-200, registered in India as VT-EGD. The aircraft was manufactured in 1980 and first delivered to Indian Airlines. It was subsequently leased to Alliance Air in 1999. The aircraft had accrued a total flying cycles of 51,278 cycles. Two Pratt & Whitney JT8D/17A engines powered the aircraft, each developing approximately of thrust at sea level. The left engine and the right engine had gone through a total of 13,931 hours and 9,387 hours, respectively. The aircraft was to be phased out by the end of the year per Indian government guidelines which do not allow aircraft over 20 years old to operate in Indian airspace.
The aircraft had been involved in an earlier accident. On 15 January 1986, the pilot of the aircraft attempted to land at Tiruchirapalli in conditions below weather minima. During go-around, the wing contacted the runway due to an excessive bank angle. The wing was substantially damaged, but there were no injuries among the 6 crew and 122 passengers. The pilot displayed great skill in manually flying the aircraft at FL100 (approximately ) and diverted to Chennai and landed safely with flight controls in "manual reversion" on runway 07.
Passengers and crew Flight 7412 was carrying 52 passengers and 6 crew members, including 2 flight crew and 4 cabin crew. Most of the passengers were Indian nationals. The passengers comprised 44 men, 5 women and 3 children. Among the passengers were 4 members of a single family from Glasgow. A total of 6 people had boarded the flight to Lucknow, while the other 46 were heading to Patna.
The pilot flying was 31-year-old Captain Arvind Singh Bagga. He had a total flying experience of 4,085 hours, of which 3,605 hours were on the Boeing 737. The pilot not-flying was 35-year-old Captain Manjit Singh Sohanpal. He had a total flying experience of 4,361 hours, of which 1,778 hours were on the Boeing 737. Both flight crew were described as experienced pilots.
Accident Flight 7412 departed Calcutta (now Kolkata) at 06:51 local time on 17 July 2000 for a flight to the Indian capital of Delhi, with stops at Patna and Lucknow, carrying 52 passengers and 6 crew members. The aircraft was flown by Captain Bagga with Captain Sohanpal as his co-pilot. The flight was uneventful until its approach.
At 07:12 a.m, the aircraft was handed over to Patna following its take-off from Calcutta. At 07:17 a.m, during the approach, Patna ATC asked the crew to report for descent and also to check descent traffic with Calcutta Area Control. The aircraft was then cleared for descent to flight level 75 (approximately ) and eventually to . Flight crews were asked to report for an approach to runway 25.
The flight crew reported commencing the turn to Patna at 07:28 a.m and three minutes later they reported crossing the airport area and coming up on the localiser. The aircraft was then asked to descend to . Patna ATC later cleared the aircraft to land at Runway 25. The flight crew, however, noticed that their altitude was much higher than the usual altitude for an approach and requested the ATC for a 360-degree orbit. The ATC granted their request and asked the crew to report back on the approach, which the crew acknowledged. This was the last transmission from the crew.
Following the aircraft's clearance for a circle, the flight crew attempted a turn to the left. At the time, the aircraft was flying above Patna's Secretariat Tower. During the left turn, the stick shaker activated, warning the crew on the impending stall condition. The aircraft continued to bank, losing its altitude and eventually grazed trees and a single-storied house in a government residential housing estate, crashing in a government residential colony behind Gardani Bagh Girls School at 07:34 a.m.
Plumes of smoke immediately appeared from the last area where the aircraft was last seen. Patna ATC immediately activated the crash alarm and reported the crash of Flight 7412 to fire services. Authorities arrived at the crash site approximately 15 to 20 minutes after the accident. The accident sparked fire in the area due to the aircraft's 2,5 tonnes of fuel. The search and rescue operation was hampered by the narrow roads and large volumes of people. Airport officials and police were met with anger from locals due to the chaotic situation. Dozens of onlookers even tried to climb rescue vehicles to get a better view on the crash site. The situation finally came under some control after multiple jawans and military officers were deployed to the area.
Two houses were destroyed while another house had damages on the roof. A total of seven people were found alive from the site, four of whom later succumbed due to their injuries. One passenger, a male teenager, managed to survive unscathed from the crash and was able to walk away from the wreckage. Those who survived the crash were seated at the aft fuselage. A total of 60 people, including 5 people on the ground, were killed in the crash.
Investigation A board of inquiry was appointed by India's Ministry of Civil Aviation on 8 August, with Air Marshal Philip Rajkumar from Bangalore's Aeronautical Development Agency as the head of the board. As the state of the aircraft's manufacturer, the United States sent representatives to India to assist the investigation of the crash. Those included representatives from Boeing, NTSB and the FAA. Public hearings were held and a total of 41 testimonies from witnesses of the crash were examined.
Airworthiness issue In the immediate aftermath of the crash, many initially blamed the crash on the old age of the aircraft. The aircraft was manufactured in 1980 and thus many believed that the flying ability of the 20-year-old aircraft had been depleted. There were a number of aspersions cast on the maintenance of flights by Alliance Air, with the then civil aviation minister Sharad Yadav reportedly unhappy with the maintenance of the aircraft and asking for replacement of a number of additional aircraft. The aircraft itself had been involved in an accident in January 1986 in which one of its wings had accidentally grazed the ground, causing substantial damage. The technical logs, however, revealed that the damage was repaired in immediate effect with a "satisfactory result".
Just two weeks before the crash, the British Foreign Office had warned Britons not to board Alliance Air following the withdrawal of a service contract by Rolls-Royce. According to reports, "safety grounds" were cited as the reason of the withdrawal.
While ageing is one of the main concerns in the aviation industry, an aircraft is still deemed as airworthy as long as the operators follow the required modifications and conduct adequate maintenance on the aircraft parts. In the case of Flight 7412, the aircraft had undergone a C check, the highest category of major maintenance check for a Boeing 737-200, between November 1999 and January 2000. The aircraft had been involved in a program for ageing aircraft, called as Corrosion Prevention and Control Program (CPCP), aimed to control and prevent corrosion on the airframe. It had also followed the required modifications for ageing aircraft.
Another airworthiness issue on the crash was the type of the aircraft. Prior to the crash of Flight 7412, the type of the aircraft, the Boeing 737, was a subject of an issue that rocked Boeing in the 90s. The issue stemmed from a malfunction on the aircraft's rudder which caused the crash of two passenger aircraft, United Airlines Flight 585 and USAir Flight 427, claiming the lives of 157 people. Both flights immediately nose-dived while on approach to their destination airports. Following the accidents, the FAA cautioned aircraft operators on the issue and ordered mandatory modifications on every Boeing 737 aircraft in service.
Despite suspicions on the aircraft's airworthiness and its old age, the board of inquiry concluded that the aircraft was airworthy. There was no evidence that the aircraft's rudder had caused the crash and no defects were found in any other aircraft parts, including the engines, flaps and slats.
Flight recorders analysis The flight recorders indicated that Captain Bagga was on the left seat and Captain Sohanpal was on the right seat. Captain Bagga was the one in control while Captain Sohanpal was the one in charge with the radio communication. According to the recordings, the sequence of events were as follow:
Flight 7412 had followed the established approach procedure up until 07:28 a.m when Patna ATC asked the flight crew to start turning to the direction of the airport. The flight crew acknowledged the message. However, the aircraft didn't turn. They should have started their descent to while commencing the turn but the aircraft remained at the same altitude and heading, even though two minutes had passed since the message was sent from the ATC. The controller in Patna was given the impression that the flight crew was following the standard approach procedure to Patna, while in reality there was no intention to commence the turn. Captain Sohanpal should have briefed Captain Bagga about the matter, however the recording didn't capture any response from Captain Sohanpal.
01:56:15 Patna ATC - 7412 Roger descend to 4000 feet QNH 996 hPa, transition level flight level 55 Report 13 DME for ILS — DME ARC approach Runway 25. 01:56:23 Captain Sohanpal 4000, 996 hPa, call you commencing the ARC. 01:56:54 Patna ATC Allied 7412 latest QNH 997 H Pa 01:56:58 Captain Sohanpal 997 copied 01:56:58 Patna ATC QNH correct
The aircraft then started to bank multiple times. It first banked to the left, and then to the right, and to the left again. All of this took 3 and a half minutes with different flaps configurations; 1 degree, 5 degree and 15 degree, respectively. The crew tried to make a zig zag motion in order to lengthen their approach path, thus gradually decreasing their altitude. The aircraft had just crossed the lead radial at an altitude of and was just from the distance measuring equipment (DME). The correct procedure stated that an aircraft should have been at an altitude of and was from the DME while it was crossing the lead radial. If they were higher than said altitude and was at a closer distance than the normal flight profile then they would be at an altitude that was too high for an approach to the airport.
The aircraft crossed the extended runway centre line and entered a zig-zag motion again, first to the left and then to the right. The flaps changed from 15 degree to 40 degree. During the entire sequence, from the start of the zig-zag until 15 seconds before the crash, the engines remained at idle position. The reason why the engines were set at idle was not clear, though investigators suspected that it was due to their high altitude for an approach.