Pakistan International Airlines Flight 688 was a domestic passenger flight from Multan to Islamabad with a stopover in Lahore, operated by Pakistan's flag carrier Pakistan International Airlines. On 10 July 2006, the aircraft operating the route, a Fokker F27, crashed into a mango orchard after one of its two engines failed shortly after takeoff from Multan International Airport. All 41 passengers and four crew on board were killed.
Pakistan Civil Aviation Authority (PCAA) attributed the causes of the crash to multiple factors. One of the engines started to malfunction during the take-off roll due to improper assembly. Despite the aircraft being able to stop within the remaining runway distance, the pilots opted to continue their take-off. They failed to carry out the correct emergency procedure and as a result the airspeed rapidly decayed, ultimately stalling the aircraft.
Aircraft The aircraft was a Fokker F27 registered as AP-BAL with a serial number of 10243. The aircraft was manufactured in February 1964 and was delivered to Pakistan International Airlines in 1979. According to the logbook, the aircraft had a total flying hours of 73,591.
The engines were produced by Rolls-Royce. The left engine and the right engine were manufactured in 1959 and 1958, respectively. Both engines had been overhauled at the PIA Ispahani Hangar facility approximately one year prior to the crash.
Passengers and crew The aircraft was carrying 41 passengers. According to the manifest, 33 were men and 8 were women. All of them were thought to be Pakistanis. The passenger manifest showed that 20 passengers were heading to Lahore, while the other 21 were heading to Islamabad. Among the passengers were Lahore High Court (LHC) judge Justice Muhammad Nawaz Bhatti, former LHC judge Nazeer Siddiqui, Vice-Chancellor of Bahauddin Zakariya University Mohammed Naseer Khan, and two army brigadiers. Pakistan's The Express Tribune reported that there were seven doctors on board the aircraft. Imtiaz Anwar, an official from the airline who was responsible on the airworthiness of the Fokker fleet of PIA, was also on board.
The captain was 53-year-old Hamed Qureshi. He had a total flying experience of 9,320 hours. He graduated from Pakistan Air Force Academy in Risalpur and joined PIA in December 1989. The first officer was 28-year-old Abrar Chughtai. He had accumulated a total flying experience of 520 hours, Both cockpit crew members had less flying experience with the Fokker F27, just 138 hours for Captain Qureshi and 303 flight hours for First Officer Chughtai.
Accident Flight 688 was scheduled to take off from Multan at 12:00 p.m, with Pakistan's second largest city of Lahore as its destination. The Fokker F27 was carrying 41 passengers and 4 crew members. According to the report, the flight was to later continue to Islamabad. The weather was good when the aircraft was cleared to take off.
The aircraft was rolling on the runway at a speed of 60 - 70 knots when the crew noticed that one of the pumps had malfunctioned. After reaching approximately half of the runway, the aircraft started to veer to the right. The crew then tried to maintain the course of the aircraft and it managed to stay on the remaining runway distance. As it reached 90 knots, Captain Qureshi asked First Officer Chughtai on whether the torque on the right engine had decreased, to which First Officer Chughtai responded: "affirmative".
Five seconds later, the Fokker F27 crossed its V1 speed and the cockpit crew decided to continue the takeoff from Multan. At 120 knots, the aircraft lifted off from Multan Airport. The autofeather system then activated shortly after. The right engine suffered a flame out and began to spool down. The cockpit crew decided to manually feather the right engine. Meanwhile, the air traffic controller in Multan noticed that smoke was emanating from the right engine. They then informed Captain Qureshi on the situation and the captain tried to return to Multan. The fire alarm blared inside the cockpit.
Flight 688 began to bank several times with its landing gears extended. The aircraft reached a maximum height of 150 – 160 ft. It then stalled and banked heavily, plunging onto a nearby mango garden. Several farmers on the ground panicked as they saw the aircraft hurtling towards them. The aircraft then hit some trees and smashed into a mud wall before skidding on the ground. The nose caught a ditch, causing the rest of the aircraft to flip and eventually landed on its back. During the front roll, the tail detached and struck a nearby electric wire. It came to rest in an inverted position. The fuels on board the aircraft then ignited, creating an intense blaze.
Two minutes after takeoff, Flight 688 ceased all contact with the control tower in Multan. The aircraft crashed into a mango garden, approximately 1.2 nautical miles northeast of Multan International Airport. Local residents reported that "faint screams" from the survivors could be heard in the immediate aftermath and they immediately rushed to the scene and attempted to rescue them. However, the intense fire that had been created by the fuel on board prevented the locals to go near the wreckage. One of the flight attendants was pulled out alive, but later died on the way to the hospital. Fire brigades managed to reach the site within five to six minutes after the crash, but by that time most of the wreckage had been completely burnt. All 45 passengers and crew members were killed in the crash.
Response Incumbent President of Pakistan General Pervez Musharraf expressed his grief over the deaths of the passengers and crews. High ranking government officials also sent their condolences to the relatives of the victims. Chief Minister of Punjab, Chaudhry Pervaiz Elahi, ordered Punjab Minister Rana Muhammad Qasim Noon to visit the crash site. Pakistan Ministry of Defence stated that the government would establish a helpline in the ministry, as well as in Pakistani CAA and PIA offices in Islamabad, Lahore and Multan. Pakistan Prime Minister Shaukat Aziz ordered then-Minister of Defence Rao Sikandar Iqbal to open an inquiry into the crash.
In the aftermath of the crash, several events were cancelled in Lahore to respect the victims. Traders reportedly closed their shops and mass prayer was held in a public park on the evening of the crash. Lahore High Court was closed following the deaths of the two judges. Chief Justice of Pakistan Iftikhar Muhammad Chaudhry later visited the relatives of one of the judges. Meanwhile, the Multan Bar Association announced three day of national mourning. The Punjab Bar Council also announced a day of national mourning on 11 July.
Spokesman from PIA stated that victims' next of kin would be given compensation of up to Rs500,000.
The Air League of PIA Employees Union charged the PIA administration with responsibility for the crash. They argued that the airline operated flights with too few crew members, promoted incompetent officials, and carried out substandard overhaul work on aircraft, among other flaws. Academic Staff Association of Bahauddin Zakariya University also criticized PIA officials for the crash, demanding then-PIA chairman Tariq Kirmani to resign. They also expressed their dismay to officials from Pakistani CAA and the government regarding the safety of the Fokker F27 fleet.
Employees in PIA accused the airline of being short on maintenance workers. According to the report, approximately 30 senior engineers had left the airline since January 2006. Most of them applied to Gulf-based airlines.
Following negative sentiments from the public, Pakistani government ordered PIA to ground their Fokker fleet. Information Minister Muhammad Ali Durani stated that routes in the North of the country would be replaced with C-130 Hercules and other routes would be deliberated among officials for more consideration. The routes were later replaced with Boeing. All PIA Fokker aircraft were later withdrawn from service and replaced with ATR aircraft. Starting in November 2006, the Fokker F27 fleet would be replaced with seven ATR-42. In response to the grounding of the Fokker F27 fleet, fares of the routes were reportedly raised by PIA.
Investigation Director General of Pakistan Civil Aviation Authority announced the formation of a board of inquiry to probe the cause of the crash, headed by Air Commodore Junaid Amin. Special investigation team assembled by PIA announced that they would compile a report within a week of the accident. The investigation would take up to three months for completion. Pakistani authorities had asked assistance from multiple foreign experts, including those from Fokker, Rolls-Royce and other air crash investigation agencies. The Pakistan Airline Pilot's Association, however, criticized the move as a "farce and an eyewash" as they accused authorities, particularly PIA, of being hesitant on involving International Federation of Air Line Pilots' Associations into the probe. They later claimed that the move was a biased attempt to put the blame on the pilots.
The flight recorders were recovered from the crash site and were taken to Karachi for examination. The flight data recorder was later flown to the U.S and the cockpit voice recorder was sent to France and the United Kingdom for readout.
There were concerns regarding the condition of PIA's Fokker F27 fleet. One of the relatives of the victims of the crash had told PIA authorities to ground the Fokker F27 following a flight from Islamabad to Multan. Both cockpit crew reportedly had also filed complaint in regards to the maintenance and the airworthiness of the Fokker F27 fleet. PIA, however, reiterated that their Fokker fleet was airworthy and certified for flying. Deputy Managing Director of PIA, Farooq Shah, stated that there were no known recorded defects on the involved aircraft in the last 15 days. Pakistani CAA also claimed that the Fokker F27 fleet was airworthy.
Engine malfunction Investigators visited the crash site on the same day of the crash. Following report from air traffic control that the aircraft had caught fire during the take-off, the runway was inspected for possible clues. The team discovered a metal debris lying on the right side of the runway at a distance of 4,000 ft down the runway. The grass surrounding the area had signs of fire. While continuing through the entire length of the runway, they discovered that more pieces of metal debris had spread until at a distance of 6,800 ft.
The identification of the metal debris revealed that the pieces were actually parts of the aircraft's turbine blades, specifically from the right engine. A teardown on the right engine further revealed that the two bolts which retained the bearing of the rear turbine had cracked due to stress. A third bolt had also fractured in the same way. The stress had originated from the inner part of the ball bearing, which eventually led to metal fatigue. The inner portion had been too extensively damaged that investigators could not determine the primary source of the failure, but it was thought that the failure had occurred prior to the flight on 10 July.
Further examination showed that the clamping load on the bearing assembly had lost. Subsequently, the bearing assembly moved from its place and the turbine followed the movement of the ball bearing. This resulted in a physical contact (rub) between the rear part of the high pressure turbine (HPT) blades and intermediate pressure turbine (IPT). Due to the rub, the root neck part of the blades overheated and the blades eventually broke off in high temperature. The IPT turbines also contacted the low pressure turbine (LPT), causing fatigue as well. The resulting separation of the blades caused deterioration in the engine performance. These blades were also noted as the ones that caused the fuel to ignite during the crash.